FAA Grounds MD-11 Jets After Deadly UPS Crash

UPS And FedEx Suspend Fleets as Investigators Probe Engine Failure

UPS MD-11
The tail engine of a UPS MD-11 at UPS Worldport on Nov. 5. (Jon Cherry/Associated Press)

Key Takeaways:Toggle View of Key Takeaways

  • The Federal Aviation Administration ordered all McDonnell Douglas MD-11 planes grounded Nov. 8 for inspection after a UPS cargo jet crashed at the company’s Louisville hub, killing 14 people.
  • UPS and FedEx had already grounded their MD-11 fleets, which make up 9% and 4% of their aircraft respectively, following Boeing’s recommendation and amid safety concerns about engine detachment.
  • Investigators are analyzing cockpit recordings and crash footage to determine why the UPS jet’s left engine detached during takeoff, with findings expected in coming months.

[Stay on top of transportation news: .]

LOUISVILLE, Ky. — Federal aviation officials issued an order Nov. 8 for McDonnell Douglas MD-11 planes not to be flown pending further inspection, reinforcing cargo carriers’ decision to ground their fleets following a deadly crash at the UPSglobal aviation hubin Kentucky.

UPS and FedEx said Nov. 7 that they were grounding their fleets of McDonnell Douglas MD-11s “out of an abundance of caution,” and the Federal Aviation Administration's directive the following day sidelined the planes until inspection and correction of any problems. In the Louisville crash, the jet's left engine detached during takeoff.

“This condition could result in loss of continued safe flight and landing,” the FAA said, adding that the issue “is likely to exist or develop in other products of the same design.”



The crash Nov. 4 at UPS Worldportkilled 14 peopleincluding the three pilots on the MD-11, which was headed for Honolulu.

MD-11 aircraft make up about 9% of the UPS airline fleet and 4% of the FedEx fleet, the companies said.

“We made this decision proactively at the recommendation of the aircraft manufacturer,” UPS said in a statement. “Nothing is more important to us than the safety of our employees and the communities we serve.”

FedEx said in an email that it was grounding the aircraft while it conducts “a thorough safety review based on the recommendation of the manufacturer.”

Boeing, which merged with McDonnell Douglas in 1997, said in a statement on its website that it “recommended to the three operators of the MD-11 Freighter that they suspend flight operations while additional engineering analysis is performed."

Want more news? Listen to today's daily briefing above or go here for more info

Western Global Airlines is the only other U.S. cargo airline that flies MD-11s, according to aviation analytics firm Cirium. The airline has 16 MD-11s in its fleet but 12 of them have already been put in storage. The company did not immediately respond to an email seeking comment outside of business hours early Nov. 8.

Boeing announced in 1998 that it would be phasing out its MD-11 jetliner production, with final deliveries due in 2000.

The UPS cargo plane, built in 1991, was nearly airborne on Nov. 4 when a bell sounded in the cockpit, National Transportation Safety Board member Todd Inman said earlier Nov. 7. For the next 25 seconds, the bell rang and the pilots tried to control the aircraft as it barely lifted off the runway, its left wing ablaze and missing an engine, and then plowed into the ground.

The cockpit voice recorder captured the bell, which sounded about 37 seconds after the crew called for takeoff thrust, Inman said. There are different types of alarms with varying meanings, he said, and investigators haven’t determined why the bell rang, though they know the left wing was burning and the engine on that side had detached.

Inman said it would be months before a transcript of the cockpit recording is made public as part of that investigation process.

Jeff Guzzetti, a former federal crash investigator, said the bell likely was signaling the engine fire.

“It occurred at a point in the takeoff where they were likely past their decision speed to abort the takeoff,” Guzzetti told The Associated Press after Inman’s news conference. “They were likely past their critical decision speed to remain on the runway and stop safely. … They’ll need to thoroughly investigate the options the crew may or may not have had.”

Cox Automotive's Matt Trapp and Alex Fraser discuss how advanced technologies are shaping the future of maintenance.Tune in above or by going to .

Dramatic videocaptured the aircraft crashing into businesses and erupting in a fireball. Footage from phones, cars and security cameras has given investigators evidence of what happened from many different angles.

Flight records suggest the UPS MD-11 that crashed underwent maintenance while it was on the ground in San Antonio for more than a month until mid-October. It is not clear what work was done.

The UPS package handling facility in Louisvilleis the company’s largest. The hub employs more than 20,000 people in the region, handles 300 flights daily and sorts more than 400,000 packages an hour.

UPS Worldportoperations resumedNov. 5 with its Next Day Air, or night sort, operation, spokesperson Jim Mayer said.

UPS ranks No. 1on theTransport Topics Top 100 list of the largest for-hire carriersin North America andNo. 5on the TT Top 100 logistics companies list. It also ranks No. 2 on theTT Top 50 global freight companies list.

FedEx ranks No. 2on the for-hire TT100, No. 43on the logistics TT100 and No. 3 on the global freight TT50.